DSC, BRAKE, ABS Yellow light on the BMW325xit

I was surprised the other day while driving by a beep and the simultaneous yellow light appearing on the DSC, BRAKE and ABS symbols.

When I turned off the engine for a while the light would go out, but then after a few minutes of driving it would appear again.

The car was at the mechanic a week ago, and he was working on the front left wheel, he also disconnected the battery during his intervention. I did some research on the forums and read some instructions on how to reset this behavior (turning the wheel clockwise the counter-clockwise to the extreme, or opening and closing all doors) but it did not yield any results.

So I went to the car electrician in order to run the BMW on the scanner. The moment of truth revealed three alarms:

  • Front left wheel speed meter.
  • Brake pad.
  • Power interruption.

He told me there was something broken which needed replacement but I insisted on clearing out the alarms. He did that and I then drove it and the symptoms did not appear for a week, then they started appearing again and more frequently. As a last shot before the mechanic, I decided to do it myself and check the sensor. I removed the wheel, checked it out, re-fitted the cable connector firmly and that was it. No more orange lights, problem solved every since!

I guess the lesson learned here is that I should buy a scanner and make sure I clear the alarms each time the battery is disconnected or some sort of sensor or electrical component is replaced or refitted.

Needless to say that I have tested the ABS and DSC functionality, it’s all working like a charm.

0 comments  

Labels: ,

The X in the BMW 325xi

The BMW 325xi E46 has three differentials: one in the front, one in the middle and another one in the back.

The middle differential transfers power at a 32%/68% ratio favoring the back. This distribution, while providing a good grip to the car in wet conditions, favors the sporty driving experience in dry conditions by transferring more power to the back wheels.

The ratio is fixed mechanically and cannot be changed electronically like in other cars like Subaru or Saab.

The differentials are open and therefore do not have a Limited Slip Differential (LSD) mechanism. However the ADB-X (Active Differential Breaking) and DSC-X (Dynamic Stability Control) system, will enhance the grip of the vehicle by applying brakes and cutting off power to the wheels which are spinning. This system is controlled electronically via the central computer vs. the mechanical nature of LSD. It intervenes on each wheel individually to retain traction and is unoticeable to the driver.

The added AWD mechanism comes with a price. More than 100kg of weight which will make the vehicle stopping distance longer. However, it will make it start faster in normal conditions or get you off the snow in extreme weather.

The E90 models are fitted with the xDrive system, which is a bit more elaborated and designed to distribute the torque based on the road conditions.

To Disable DSC-X: Press the button once.
To Disable ADB-X: Keep holding the button won't work on the 325 xit model, it is only supported on the non-X E46.

0 comments  

Labels: ,

BMW OEM Mud flaps


One easy way of making the BMW E46 touring vehicle look more sporty is to fit it with mud flaps. The genuine OEM models are very discreet and stylish.

I have fitted my 325xit with two pairs (rear and front) and I should say that I am quite satisfied with the end result. Sporty but not Flashy!

Here are the references and the prices taken from realoem.com (apparently these models are not suitable for vehicles with the M Sports –or Aerodynamics- Package II):





82169408655

SET MUD FLAPS, FRONT

1

$ 23.38

82160009357

SET MUD FLAPS, REAR

1

$ 23.38

0 comments  

Labels: ,

BMW Service Codes

00110170E34/E38 M60B30 Secondary air shutoff valve
00110171E31/32/34/38 M60 automatic USA piston ring wear detectors
00110174E34 M60 HS Cylinder wear detectors
00110175E31,32,34,38 M60 Cylinder wear detectors
00110176E31,32,34,38 M60 Cylinder wear detectors
00110178E36 318tds Oil dipstick
00110179E36/M52 DME File Update (cylinder wear detectors, M52)
00110184E31/E38/E39 M62 Crankcase
00110185E38/E31/E39 with M62 - Crankcase base plate - only VPC NU
00110202R53 Replacing crankcase ventilation line
00110301E36 328iA US An additional tensioner pulley is missing
00110302E46 E60 E61 E83 M57/TU - Replacing engine (crankshaft)
00110401E36/M52 - Lambda probe plug is not located
00110402E53 M57/TU Replacing engine
00110501E36 M52 B20 Israel Cylinder barrel surface wear detector
00110502E87 M47/TU Replacing turbocharger
00110601E36 Coolant hose rubs on the oil filter housing
00110602E65 M57/TU Reworking acoustic cover for engine
00110801E39 LHD M62 - Engine support trestle rubs
00110802E46 M47/TU Replacing intake manifold
00110901E36 - O-ring between oil filter and timing cover case
00110902E60 S85 Replacing engine oil pump
00111001E36/M43 - Piston rings
00111401E36 S50 B32 VANOS needle bearing
00111501E36 M44 Front intake support (ZA only)
00111601E39 M52/B25 Special engine with cast iron crankcase (SA 961)
00111701E31 E38 M73 US short circuit/short circuit to ground in Lambda probes
00111801E36/7 E38 E39 E46 M52 LEV/EU3 Oil filter housing
00112001E36 US M44 Short circuit to eartch/open circuit in oxygen sensors
00112101E36 US M42 Routing of Lambda probe cable
00112201E46 M43 Oil dipstick too long
00112301E36 M52 B25 Retrofit special-purpose motor with GG crankcase (SA 961)
00112401E46 Replace M47 power unit
00112501E39 Coolant hose - hose spacers
00112601E36 E38 E39 E46 M41 M47 M51 vacuum pump
00112701E46 M 47 Cylinder head leakage tightness
00112801E46 M47 Replacing piping system, EGR valve, support bracket for EGR cooler
00112901E46 M47 Replacing EGR valve, piping system
00113001E46 M52 (US+RHD) Vacuum line, secondary air valve
00113101E36 E46 M43 Drive belt pulley for A/C compressor loose
00113201E39 M52 RHD Engine cover
00113301E36 E46 M41 M47 Incorrect installation of big-end bearings
00113401E38 E46 M57 M47 Replacing cylinder head bolts
00113501E36/7 (with SA 199) exhaust emission values incorrect
00113601E36/3 E38 E39 M51 Cylinder head gasket leaking
00113701E36 E46 M44 M43 Valve spring incorrectly fitted
00113801E39 M5 S62 Fan clutch
00113901E38 E39 M57 Retrofit acoustic cover edge protector
00114001E39 M5 S62 Leak from lower section of oil pan
00114101E31 E34 E38 M60 US MY95 NOx limits exceeded (oxygen sensor)
00114201E36 E38 E39 M52 Control characteristics of double-plate thermostat
00114301E31 E38 M73 US Crankcase breather
00114401E39 M5 Ground strap at cylinder head
00114501E36/7 M52 Incorrect installation of coolant hose
00114601E53 Oil dipstick incorrect
00114801E38 M62 Oil hose between oil filter and engine twisted - correction
00114901E36/2/4/7/C ECE (S50 B32) VANOS cover threaded connection
00115001E36 E39 M52 Nikasil engine conversion (CKD Vietnam)
00115101E52 S62 Quick-release couplings for oil lines
00115201E52 Tip of dipstick broken
00115401E36/5 Support for intake manifold loose
00115501E46 M54 Coolant hose without chafe guard
00115701E46 S54 Crankshaft big-end bearing - engine replacement
00115801E39 E52 S62 Replacing intake air duct of intake plenum
00115901E38 M67 Replacing camshaft sprocket + drive gear for high pressure pump
00116001E46 S54 Finger retaining clip
00116101E36/7 E39 E46 M52TU Characteristic map thermostat
00116201E36/7 E46 S54 Oil change
00116301R50 R53 (MINI) Engine oil change - SIA
00116401E46 S54 Intake camshaft oil lubricating channel
00116501E46 S54 Crankcase oil hole
00116601E36/7 E39 E46 M52 (US) Crankcase breather
00116701E46 M47TU Replace turbocharger
00116801E46/5 N42 (SA 842) Crankcase ventilation
00116901R53 Replacing vibration damper
00117001E46 N42 (CKD) Balancing shafts
00117101E46 N42 Replacing banjo bolt in cylinder head
00117201E38/3 Oil pump bolt connection
00117401E53 M57 Reworking intake system
00117501E46 M54 Checking oil duct supply (VPC Japan)
00117601E46 S54 Big-end bearing
00117701E46/4 M47/TU (ZA) Replacing exhaust turbocharger
00117801E85 M54 Retightening threaded connection of belt tensioner for air conditioner drive
00117901E46 M54 Replacing bracket for secondary air pump
00118001E46 M47/TU Reworking threaded connection for vibration absorber
00118101R50 W17 Check hose clip on pressure hose for intercooler
00118301E46 M47/TU (ZA) Replacing exhaust turbocharger
00118401E65 E53 E46 M57 Replacing crankcase breather line
00118501E65 E66 Retightening oil drain plug
00118601E60 E63 E65 E66 N62 Replacing intake manifold
00118701E53 M54 Replacing belt tensioner
00118801E60 N62 Adjusting minimum valve lift, Valvetronic
00118901E65 E66 E67 N62 N73 Replacing check valve
00119101E53 HP Removing tab on dipstick guide tube
00119201E46 E60 E65 E83 M57/TU Piston coating defective
00119301E46 M47/TU (SA 185 / 186) Replacing torsional vibration damper
00119401E46 S54 Replacing connecting rod bearing shells and connecting rod bolts if necessary
00119501E46 S54 Replacing big-end bearing shells (2. KDB)
00119701E53 Replacing N62 B48 engine
00119801E46 M57/TU Replacing dipstick
00119901E46 E60 Replacing engine
00120111E30/M20 Japan wearing protection for motor wiring harness
00120158E38 M60 Oil level sensor
00120159E38 M60 (with independent fuel burning heater) cold start
00120160E36 M52 B20 Protective pipe on battery+ hose
00120161E36 M52 B20/B28 DME-electronic control unit, final stage
00120163E34 DME Fault storage
00120166E31/E38 M73 Ignition unit priming plug
00120201E36 M52B28 US Incorrect program status OBD2
00120301E36 M52B28 US Incorrect poling of the secondary air pump
00120302E85 M54 Retrofitting power supply for thermal oil level sensor (TÖNS)
00120501E31 M73 Replace the pedal evaluator
00120601E31 M73 Block up the electronic engine performance regulator bypass hose
00120701E38 M73 Check the pedal evaluator
00120801E38 M73 Check the electronic engine performance regulator wiring harness connection
00121001E36 S52 Overspeed storage in the DME-electronic control unit
00121101E31,E34/M60,M62 Porous oil level float switch
00121201E38,E39 M51,M52,M62,M73 Failure of the safety module
00121301E39 DME-electronic control unit - chassis number not programmed
00121401E36/S52 DME Data status
00121501E36/Z3 US with M52B28 - DME Data status
00121601E36 E39 M52 B28 US (not including Z3) DME fault code entry, oxygen sensor
00121701E36/M44 Engine wiring harness/line to injection valves
00121801E46 M43, M52 Connector on crankshaft pulse generator not clipped in
00121901E36/5 M43 B16 DME malfunctions/failure
00122001E46 M43 M52 Camshaft pulse generator
00122101E46 M43 Failure of oil-level sensor
00122301E46 M52 B25 (Belgium) incorrect construction DME control unit
00122501E38 E39 M62 B+ starter cable defective
00122601E46 M43 Seal for plug connector of oil level sensor
00122701E36 E39 M52 S52 US Crankshaft position/rpm sensor failure
00122801E39 M5 S62 DME control unit + engine oil
00122901E38 M73 LEV US Wiring harness fault at DME control unit
00123101E38 E39 M62 M73 LEV Alternator regulator malfunction
00123201E46 M52 US (with SA 205) Fault code memory check not possible with Scan Tool
00123301E39 M5 Engine wiring harness chafing
00123401E38 Threaded connection of battery negative lead loose
00123501E46 E36/C Threaded connection of battery negative lead
00123601E36/7 E39 E46 M52 US OBD Fault memory inquiry/readiness code
00123701E39 E52 (preproduction) S62 DME main relay
00124001E36/7 M52 Engine cooling - reprogramming DME
00124101E39 M5 US Readiness Code cannot be read out
00124201E38 M73 Increasing idle speed
00124301E38 M73 Replacing drive belt and alternator
00124401E39 E52 S62 DME control unit defective
00124501E52 (ECE) E-OBD interface
00124601E52 B+ battery lead installed incorrectly
00124701E46/5 316ti A DME control unit program change
00124801E46/16 M54 Reprogram DME control unit
00124901E53 M54 US DME control unit: Thermostat diagnosis
00125001R50 R53 (MINI) Battery positive lead chafes against coolant hose
00125101E52 S62 B+ cable fitted incorrectly
00125201E36/7 E46 M52B20 Reprogram DME (engine cuts out)
00125301E46 N42 Alternator, faulty threaded connection
00125401E36/7 E39 E46 E53 M54 DME ECU Program - (E-)OBD lamp activation
00125501R50 US DME Program control unit - emission check
00125601E46 Replace alternator
00125701E36/7 E39 E46 E53 M54 Programming DME control unit
00125801E65 E66 Replacing integrated supply module (IVM)
00125901E39 E46 M54 - Wiring harness engine ignition module
00126001E46 M56 Adapter terminal 30 H
00126101E46 M54 M56 Replacing starter motor
00126201E46 M56 Programming DME control unit
00126301E53 M54 Programming DME control unit (A/C compressor)
00126401E85 Programming DME control unit (oil level warning threshold)
00126501R50 (CVT) Programming DME control unit
00126601E85 Programming DME control unit (fan)
00126701E46 M56 Programming DME (knock control)
00126801E46 M56 Programming DME (idle speed stability)
00126901E65 E66 N73 Programming DME control unit
00127001E65 E66 N73 Changing vehicle order (retrofitting SA 858)
00127101E46 N42 Replacing ignition coil
00127201E65 E66 N62 Programming DME control unit
00127301E65 E66 N62 Replacing ignition coil
00127401E65 E66 N62 Programming DME control unit
00127501E85 Programming DME control unit (fuel tank vent valve check)
00127601E46 N42 Replacing alternator
00127801E46 S54 CSL Replacing screws for throttle valve actuator
00128001E46 N42 A Programming DME control unit
00128101R50 R53 US Programming DME control unit
00128201E83 Programming DME control unit (fan application)
00128301E53 E60 E63 E65 E66 N62 Programming DME control unit
00128401E83 M57/TU Retrofitting adapter lead for crankcase breather heating element
00128501E60 M54 B30 US Programming DME control unit
00128601E60 M54 B30 Programming DME control unit (catalytic converter heating)
00128701E53 E65 E66 N62 N73 Programming control units (closed-loop lambda control diagnostics)
00128801R50 R53 US Programming DME control unit
00128901E60 M54 US Programming control units (DME control unit)
00129101E53 M54 (manual gearbox) programming DME control unit (handling)
00129201E87 N45 Replacing DME control unit (condenser)
00129301N62 N73 Replacing DME control unit (condenser)
00129401E46 N45 Replacing DME control unit (condenser)
00129501E87 Retightening screw connection, battery ground point
00129601E60 M54 B22 (Automatic) Programming DME control unit
00129701E87 N46 Programming DME control unit (oxygen sensor)
00129801E60 E63 E64 N62 US Programming DME control unit (diagnosis, lambda control)
00129901E83 M47/TU Correcting routing of wiring harness to crankshaft speed sensor
00130142E36 S50/B30 Throttle valve potentiometer
00130401E31 E38 M73 Exchange the throttle valve protection
00130501E31 E38 E39 M62 - Injection strip
00130601E36/316G, E34/518G - CNG/DME electronic control unit file update
00130701E36, E38, E39 with M52 - Coolant hose for throttle valve preheating
00130801E36 US - 3/2-way valve on body floor assy
00130901E39 M52 CKD mounting of injection rail on intake manifold
00131101E38 E39 M57 DDE control unit, capacitor defect
00131401E38 E39 M51 Converting engine breather hose
00131501E34 E36 518g 316g Replacing pressure control unit
00131601E39 M51 Seal for fuel feed line
00131701E39 M5 Formed hose in idle system
00131801E39 E46 M57 Engine stalls during warm-up phase
00131901E38 M67 Fuel filter
00132001E46 M54 B30 Fuel filter pressure loss
00132101E46/4 M57 A DDE data status incorrect
00132201R50 (Mini) Fuel rail
00132301E38 M62 (with SA 823) Air cleaner element in intake silencer
00132401E46/5 N42 Fuel line
00132501E38 E39 E46 E53 M57 Transmission emergency program (DDE control unit)
00132601E46 M47 (318d) Reprogram DDE control unit
00132701E65 Rubber gaiter on throttle assembly
00132801E46 M47/TU Program DDE (exhaust turbocharger)
00132901E65 N62 Replacing throttle valve assembly
00133001E65 M57/TU Reworking intake port
00133101E65 M57/TU M67 Reworking threaded connection for charge air temperature sensor
00133201E46 M47/TU Programming DDE control unit
00133301E46 M47/TU (ZA) Programming DDE (exhaust turbocharger) - prior to delivery
00133401E65 M57/TU RHD Programming DDE control unit (Tempomat)
00133501R50 W17 Replacing DDE control unit
00133601E65 E66 N73 Replacing fuel injectors
00133701E65 E66 E67 N73 Fuel line, loose
00133801E65 M57/TU M67 Checking injectors
00133901E46 M47/TU Checking injectors
00134001E46 M47TU Replacing presupply pump
00134101E46 M47/TU Checking injectors
00134201R50 W17 Programming engine control unit (DDE)
00134401E46 M57/TU Replacing pre-supply pump
00134501E83 M57/TU Replacing unfiltered air gaiter
00134701E83 M57/TU Securing fuel lines
00134801E60 M57/TU Reworking plug connection for crankcase breather heating
00134901E60 E63 E64 N62 Retrofitting clip for quick-release coupling of fuel line
00135001E83 M54 (SA 199) Retrofitting plug at fuel tank vent valve
00135101E87 M47/TU Installing bypass plate in air cleaner housing
00135201E60 E61 M57/TU Programming DDE control unit (diesel particle filter)
00135301E60 E61 M57/TU Replacing hose for exhaust backpressure sensor
00135401E87 N45 N46 Retrofitting clip on fuel line
00160102E34 Preparation of the catalytic converter - assembly mistake during tank aeration
00160112E36 M50 US Tank aeration line
00160114E38 M60/62/73 Fuel pipe in the engine space
00160115E38 - Fuel pipe in the engine space (without USA,Canada,Japan)
00160301E36 M42 LA804 Closed active carbon filter drain hose
00160401E36/Z3 Contaminated fuel tank
00160501E36/4 US Incorrect fuel pipe
00160801Z3 /M44, M52 - Fuel line makes contact with carbon canister
00160901E36 without /5/7 Fuel supply line at delivery unit
00161201E46 Fuel return line leaking
00161401E46/C US Distributor (fuel system) incorrect
00161501E46 Expansion tank hose clamps
00161601E46 E52 Fuel tank leakage diagnosis module
00161701E36/2/3/4/C Leak in fuel hose at in-tank pump
00161801E53 Breather connection piece, fuel tank leak
00161901E38 E39 Carbon canister
00162001E53 Tank system fitted incorrectly
00162101R50 Fuel feed line
00162201E38 Hose clip, fuel line
00162301R50 R53 MINI Fuel filler pipe
00162401R50 R53 MINI fuel hose chafes against clip
00162601R50 R53 Ground strap, fuel filler pipe
00162701E53 Fuel suction jet pump O-ring
00162801R50 R53 Replacing fuel filler pipe
00162901E46 - Checking vent line to carbon canister
00163001E60 Fuel tank mounting
00163101E85 Replacing pressure regulator
00163201E46 M56 Replacing carbon canister
00163301E85 Replacing fuel tank screw cap
00163401E39/2 Replacing suction jet pump
00163501E85 Retrofitting resistor for fuel pump
00163601E83 M57/TU Replacing fuel tank
00163701E53 Reworking lock mechanism for suction jet pump
00163801E87 Replacing fuel pump
00170114E34,36 M42,43,44 Radiator (jammed)
00170401E46 Cooling module, radiator adjusting screw
00170501E31 E32 E34 E36 Replacement of radiator cap (USA)
00170601E31 E32 E34 E36 Replacement of radiator cap (rest)
00170801E38 M73 Ventilation line to expansion tank closed off
00170901E38 E39 M62 LEV Coolant return hose chafes against metal gasket
00171001E53 M62 Transmission oil cooler line
00171101E46/5 Electric fan
00171201E46 Electric (main) fan
00171301E46 Electric (main) fan
00171401E39 E46 E52 E53 Replace radiator cap
00171501R53 Intercooler bolt connection (corrosion)
00171601R50 (SA 823) Radiator hose rubs against alternator
00171701E46 N42 Checking routing of coolant hose
00171901E65 M57/TU M67 Replacing intercooler
00172001E65 E66 N62 Retrofitting mounting bracket for transmission oil cooler pipe
00180104E36/5 Heat shield plate
00180201Z3 Exchange catalytic convertor
00180301E36 M52 Catalytic convertor screw connection /secondary silencer
00180401E36/7 Z3 M44 Exhaust system damper is missing
00180501E36/5 M52 Exhaust system mounting bracket
00180701E39 M52 LHD Retrofit additional exhaust support
00180801E53 Exhaust pipe extension, sharp-edged
00180901E36/4/7 M44 US Replacing catalytic converter
00181001E46 N42 Upgrade to EU4
00181101R53 Tailpipe trim
00210101E36/M41 Clutch pipe is broken
00210301E46 M47 clutch line leaking
00210401E39 M57 RHD Incorrect installation of clutch slave cylinder
00210501E36 E46 Clutch release bearing incorrect
00210601E46 Clutch release bearing
00210701R53 US/Japan Screw connection, clutch to two-mass flywheel
00210801R50 Routing clutch pipe
00210901E39 RHD Checking clutch slave cylinder
00211001E83 Replacing throttle valve, clutch hydraulics
00220201E39 540iA US Bumper on the cross member transmission
00220301E39 M52 Engine supporting arm torque is too low
00220401E38 E39 Screw connection of engine mounting bracket
00220501E52 Replacing left engine support arm
00220601R50 (Mini) Engine mount tightening torque
00220701R53 Gearbox mount threaded connection
00220801E65 E66 Threaded connection, right engine mount on engine mounting bracket
00230104Z3 M43/M44 Shift transmission oil change
00230301E36 E39 E46 Transmission oil drain plug leaking
00230401E36 M3 (for option SA 793) Connector gear detection potentiometer
00230501E36 E46 gearbox securing bolt
00230601E46 S54 (SMG) Replacing gear recognition switch
00230701E46 S54 Replacing pipe clamp at SMG gearbox
00230801E46 M54 Replacing SMG gearbox sensors
00230901E46 M54 Replacing SMG clutch position sensor
00231001E46 M54 Replacing manual gearbox
00231101E60 SA 206 Replacing SMG control unit
00231201E46 E85 SA 206 Replacing H-SMG control unit
00231301E85 Programming H-SMG control unit
00231401R50 R53 Checking transmission - engine threaded connection
00231501E46 S54 SMG Changing pin assignments for relay
00231601E46 US Programming SMG control unit
00231701E46 S54 Programming SMG control unit
00231801R50 R52 R53 Checking oil fill in manual transmission and topping-up if necessary
00231901E60 E61 M54 SMG Reworking power supply for SMG control unit
00232001R50 R52 R53 Checking oil fill in manual transmission and topping-up oil if necessary (KDB)
00240114E31 M73 US Transmission wiring harness
00240120E36/323iA LA Japan - Exchange electronic transmission control unit (Jatco transmission)
00240121E36 323iA Electronic transmission control unit (Jatco)
00240122E38 725tdsA Transmission control unit lockup clutch converter
00240201E38,39 M52 Faulty transmission control unit
00240801E38 M51 AGS control unit, data status faulty
00241101E38 E39 Automatic transmission (5HP24), ring gear faulty (extension)
00241201E46 M52 LHD US Drumming noise while coasting in 3rd gear (GM5)
00241301E38 M62 B35 A-clutch casing 5HP24
00241401E39 E46 M54 (with 5HP19) Replace transmission position switch
00241501E36/7 E46 E53 M54 Programming/replacing EGS control unit
00241601E53 M62 Transmission position switch
00241701E39 E46 (5HP19) Replace oil screen on automatic gearbox
00241801R50 Automatic transmission adaptation
00241901E39 M54 Replacing transmission position switch GM5
00242001E46 N42 Replacing cover plate for gearbox casing
00242101E46 - Pressure regulator GM5
00242201R50 CVT Replacing transmission oil
00242301E46 M54 US Programming EGS control unit
00242401E53 M57/TU Threaded connection, bracket for transmission oil cooler pipe
00242501E60 Replacing automatic transmission
00242601E53 N62 Retightening gearbox - engine screw connection
00250201E36 - Incorrectly built in gear lever rod
00250301E46 M47 Shift lever knob, vibration absorber ground loose
00250401E46 M52 LHD US Steptronic shift block
00250601E39 S62 Shift knob titanium line
00250701R50 ECVT Check automatic selector lever catch
00250801R53 US Replace transmission gearshift cable
00250901R50 Gearshift cable on reversing lever
00251001R50 Retaining bracket on gearshift cable
00251101E87 Replacing selector arm
00260101E36 Propeller shaft screw connection
00260201735iA,523iA,528iA CKD - Propeller shaft screw connection seal on input flange/differential 00260501 E39 M52 M54 Threaded connection of flexible coupling on propeller shaft
00260601E38 E39 E46 Threaded connection, propeller shaft with rear axle differential
00260701E39 Threaded connection for propeller shaft at rear axle differential
00260801E65 E66 Propeller shaft centring sleeve
00260901E65 M57/TU Replacing flexible coupling
00261001E46 M57 Retightening threaded connection for propeller shaft
00261101E60 M57/TU Checking propeller shaft and replacing if necessary
00270101E53 Checking oil filling for transfer box
00270201E83 Replacing transfer box
00310113E36/4 Spring strut
00310114E36/5 Front axle wishbone screw connection
00310115E34 Front axle cross beam
00310117E36/4/5 Lower spring strut screw connection
00310201E38 Front axle springs break
00310701E36 Wishbone screw connection on engine mount
00311301E39 Swivel bearing
00311401E39 Screw fitting of tension strut on swivel bearing
00311601E39 M5 Threaded connection for stabilizer link
00311701E53 M62 Front axle differential O-ring, oil pan
00311801E46/16 Front axle carrier, threaded insert
00311901E53 M54 Front axle differential, oil change - Bremerhaven
00312001E53 M54 Front axle drive oil change - 1500km
00312101E53 M54 Front axle drive oil change - 1st engine oil service
00312201E38 Replacing front axle spring and spring mount
00312301R50 MINI Replace control arm
00312401R50 R53 MINI Replace front axle carrier
00312501E39 E46 Mount, front spring strut
00312601E39 E46 Support bearing, spring strut front (without VPC)
00312701E46 Bolt connection, spring strut front
00312801R50 Replace output shaft
00312901E66 Replacing spring strut, front
00313001E60 Replacing coil spring, front axle
00313101E53 Reworking threaded connections on engine
00313201E65 E66 Replacing front stabilizer bar
00313301E39 Retrofitting retaining clip on front strut tower
00313401E46 (with SA 815) Retrofitting rough road package
00313601E67 Replacing front axle springs
00313701E65 E66 Checking EDC front axle shock absorber and replacing if necessary
00313801E87 Reworking screw connections on front axle
00320122E36 320i/4 325i/4 US Knee protector stiffening brace
00320123E34 Wishbone tapered spigot
00320124E34/E36 M50 Duroplast belt pulley
00320125E36/5 Steering stop limit
00320126E38/M62 RHD - Heat shield plate for track rod
00320127E39 Track rod screw connection
00320201E39 M62 LHD Power steering heat shield hose lies on the exhaust manifold
00320301E31,32,34,36 Locking unit in the steering wheel in broken
00320401E36 RHD Steering spindle corrosion
00320501E36/5 RHD Steering spindle screw connection
00320601E36 Z3/318i US Steering wheel screw connection
00320801E36/7 Z3 Airbag module screw connection
00320901E39 M52 Steering assistance pump mounting connection
00321001E36 - Steering angle limiter is missing / incorrect tyre setting
00321501E34/M50 Duroplast pulley for power steering pump
00321601E39 M52 Power steering expansion hose
00321701E36 M50 M52 Power steering pump pulley (ZJ only)
00321801E36 Steering lock limiter not installed
00322101E36/5 E46 Track rod threaded connection, front axle
00322301E38 M73 LEV RHD Incorrect installation of steering expansion hose
00322401E46 M52 Flexible coupling threaded connection
00322501E39 M5 Power steering pump threaded connection
00322901E53 Double joint at bottom of steering shaft scrapes against engine support
00323001E36/5 E46 Track rod threaded connection
00323301E53 (With SA 216) steering wheel return inadequate
00323401E53 M54 US Steering column installed incorrectly
00323501E46 Toe setting, front axle
00323601E53 Track rod at steering gear, threaded connection, axial joint
00323701E36 RHD Steering spindle corrosion
00323801E53 Bottom of steering shaft at double joint
00323901E52 Retrofitting electric steering lock ELV adapter lead
00324001E53 Threaded connection, power steering pump pulley
00324101E46 N42 Check routing of pressure hose for steering
00324201R50 R53 US Steering angle sensor mounting
00324301E39 E46 M54 Replacing power steering pump
00324401E46 Tightening down steering wheel screw connection
00324501E46 Threaded connection for track rods
00324601E39 Threaded connection for power steering gear on front axle carrier
00324701E46 Adjusting toe-in
00324801E46 Checking track rod threaded connection (scope II)
00324901E65 E66 Checking power steering
00325001E65 E66 Checking breakaway torque of power steering pump pulley (VPC)
00325101E65 E66 Power steering pump pulley
00325201E60 Active steering - replacing wiring harness and control unit
00325301E60 Active steering - replacing wiring harness
00325401E60 M54 Checking hose clip for return line of power steering system
00325501E83 Retrofitting Pentosin sticker on expansion tank
00325601E60 M54 (SA 217) Replacing radiator return line
00325701E60 E63 E64 N62 (SA 217) Replacing radiator return line
00325801E46 318i Correcting position of lines (power steering)
00325901E60 E63 E64 Replacing cover for engine position sensor (active steering)
00326001E46 Checking screw connection of steering shaft
00326101E46 M54 RHD Correcting routing of expandable hose for power steering
00326201E83 M57/TU Checking high-pressure line for power steering
00326301R50 R53 (with SA 508 and SA 895) Changing pin assignments for relay of auxiliary fan
00326401E60 E61 M57 (with SA 229) Replacing ARS line
00330111E36 M3 Rear axle bearing
00330113E38 Rear axle wheel mount
00330116E34 Rear axle screw connection
00330118E38 Rear axle carrier
00330401E39 - Check rear axle shaft wheel fastening
00330601E39 Deviation of rear left bearing from ideal tolerance
00330701E39 Deviation of rear right bearing from ideal tolerance
00330901E39/2 - Rear axle beam
00331301E39 - Swinging arm screw connection at front of rear axle carrier
00331801E46 M47 Weld, vibration absorber support bracket
00332101E38 E39 E46 M47 M52 M62 Threaded connection of crown gear in rear axle differential
00332201E39 M5 Rear axle bracket replacement
00332301E36 E46 Eccentric screw, control arm
00332401E46 Wheel bearing threaded connection
00332501E39 540iA Output shaft not hardened
00332801E39 M5 Diameter of stabilizer bar at rear axle
00332901E46 M57 A Rear axle vibration absorber not fitted
00333001E38/3 Rear axle control arm
00333101E38 E39 Threaded connection of output shaft to flange of rear axle differential
00333201E39 Rear axle threaded connection
00333301R50 (MINI) Semi-trailing arm, rear axle
00333401R50 MINI Threaded connection of semi-trailing arm to body
00333501E65 (HEA) Check position of output flange on rear axle differential
00333601E65 Check integral link
00333701E65 Replace eccentric screw guide control arm
00333801E65 E66 Replace cover on rear axle differential
00333901E65 E66 Checking output shaft
00334001E66 Threaded connection for vibration absorber, rear axle differential
00334101E66 Threaded connection for vibration absorber (VPC)
00334201E39 Checking rear axle carrier
00334301R50 R53 Threaded connection, spring strut (VPC)
00334401E39 Checking RA stabilizer bar
00334501E39 Checking and if necessary replacing rear axle stabilizer bar
00334601R50 R53 Threaded connection, semitrailing arm, rear
00334701E60 Threaded connection, output shaft to final drive flange
00334801E53 Checking threaded connection of final drive
00334901E46 Retrofitting rear adapter and damper for rough road package
00335001E87 Retrofitting plug on final drive unit
00335101E87 Retrofitting plug in final drive unit (188L)
00335201E87 Checking rear control arm and traction strut
00335301E87 Checking position of rear control arm and traction strut
00340112E36 Japan Break fluid return pipe
00340113E36 RHD ABS electronic control unit
00340114E36 Brake boost
00340115E36 ABS-Sensor
00340116E38/E39 M52 - Induction manifold bracket
00340301E31 - Leaky master brake cylinder
00340401E31,38,39 Leaky hydraulic-unit discharge damper membrane
00340501E38 Brake pipe rubs on the rear axle carrier
00340601E36 M52 S50 Incorrect vacuum hose
00340801E36 - Rubber bushing ABS Mark 20
00340901E38/750i/L Replace DSC 3 (dynamic stability control)
00341001E36 - Replace ABS Mark 20 electronic control unit
00341101E36 US/Compact, Z3 with M44 - ASC spare wheel recognition
00341201E36 - Brake boost/master brake cylinder
00341401E39 540iA Steering angle sensor matching DSC 3
00341501E38 RHD - 750i/L/L7/3 - Vacuum hose brake booster
00341601E39 Rear ABS sensor
00341701E36/7 ABS hydraulic modulator connection
00341801E39/2 Brake hose connection
00341901E46 RHD vacuum hose brake booster scuffing on earthing point
00342101E38 M62 M73 Software change ABS 5.7
00342201E39 M52 RHD Brake booster, incorrect vacuum hose
00342301E36/7 Vacuum hose clip
00342401E38 M67 DSC 3 Improved control function
00342601E39 Hydraulic unit, hole
00342701E52 Brake caliper bolt connection on front axle
00342901E38 E39 M57 E46 RHD M47 Vacuum hose, brake system
00343001E46 (330xiA ECE) DSC variant coding data incorrect
00343101E53 Mounting, pedal assembly - brake booster
00343201E46 S54 Parking brake threaded connection
00343301E46/16 Brake/fuel line spacer
00343401E53 Threaded connection, brake hose to brake caliper
00343501E46 Replace brake booster
00343601R50 R53 Parking brake pushbutton cap
00343701E46 (325ix) Replace rear brake discs
00343801R50 R53 Replacing handbrake lever
00343901E65 E66 Bending cable bracket for brake pad wear indicator
00344001E65 E66 US Correcting brake pad wear indicator
00344101R50 R53 RHD (GB, Japan) Replacing handbrake lever
00344201E53 Retrofitting brake hose retaining clip, front axle
00344401E39 E46 Brake fluid, CKD Indonesia
00344501E53 LHD Reworking brake line
00344601R50 R53 Checking rear brake lines
00344701E67 Replacing front brake caliper
00344801E60 E63 E64 E65 E66 E67 E83 Replacing rotation rate sensor
00344901E46/4 318d Replacing brake discs, brake calliper and stabilizer bar on rear axle
00345001E60 E63 E64 E65 E66 E67 DSC Replacing rotation rate sensor
00350301E36 / Z3 Accelerator pedal mounting
00350501E31, E32, E34, E36, E38 - Cruise control/bowden accelerator cable assy
00350601E36 / Z3 - Bowden accelerator cable assy fitted incorrectly
00350701E39 RHD Thrust-rod bolt, clutch pedal (prod. 01/96-08/97)
00350801E39 RHD Thrust-rod bolt, clutch pedal with bracket for clutch switch (prod. 009/97-
00350901E46 USA/CAN Brake pedal retaining clip
00351001E46/2 RHD Replacing accelerator cable assy
00351101E46 Accelerator pedal module ASCI defective
00351201E52 Incorrect installation of accelerator pedal module
00351301E53 Fixing bearing shaft in pedal assembly
00351401E39 M57 M62 S62 Replacing clutch pedal
00360113E36/5 SA337 Tyre setup
00360114E36 M3 Size of rims in the automobile papers
00360115E39 Damage to tyres
00360401E39 Damage to front right tyre
00360901E36/5 - Check wheel nuts
00361001E38, E39 - Adapter for wheel nuts is missing
00361101E39/2 Tyres, incorrect speed class installed
00361201E39 M5 Threaded connection for rear wheel
00361401E53 Tyre damage
00361601E46/C Spare wheel (space saver spare wheel) incorrect
00361701E46 Wheel stud adapter incorrect
00361801E46 US B25 (with SA 203) Tyres incorrect
00361901E46/4 (ZA) Check wheel stud tightening torque
00362001E46/3 Incorrect tyre data in vehicle documents
00362101E46 Rims damaged during assembly
00362201E38 (SA 780) Tyre damaged on inside
00362301E38 E39 E46 (18" tyres) checking tyres
00362401E38 "Run-flat" safety tyres
00362501E53 Wheel stud lock adapter incorrect
00362601E46 E39 Check outer side of tyre
00362701E46/4 ZA Wheel bolt lock
00362801R50 R53 Check tyres
00362901E53 Electronic wheel module RDC failure
00363001R50 R53 Checking left tyre
00363101E65 E66 Recoding RDC
00363201E65 E66 Changing RDC vehicle order (removing SE 876)
00363401E85 Replacing tyre
00363501E39 Checking tyres
00363601E46 Replacing adapter for wheel stud bolt
00363701E46 Checking wheel studs and replacing rim if necessary
00363801E83 Checking code - wheel stud
00370301E53 Two-axle air suspension retrofit
00370401E38/3 Replacing pressure line for ride-height control system
00370501E67 Checking rear shock absorber
00370601E53 Replacing rear air spring
00370801E67 Replacing shock absorber and mount, rear
00370901E61 Checking rear air spring and replacing if necessary
00410110E34 Metal padding in the boot/trunk
00410114E38 Front end screw connection
00410201E36 with SA 786 - Flanging for 17" tyres
00410401E32/3 Mounting of rear-axle bracket tears
00410501E38 Water ingress body engine compartment
00410601E38 LHD Automatic, water ingressing through bulkhead
00410701E46 Spring strut dome seal, rear left
00410801E39 Adjust boot-lid gap dimension
00411001E36/7 Coupe Crack in B-pillar
00411101E39/2 Cracking in tailgate
00411201E53 Seat belt anchorage, rear
00411401E46/3 Mounting, bracket for net partition
00411501E52 Water drain, sill
00411601E53 Crack in area of shock absorber mounting
00411701E53 Screw missing in tailgate
00411801E46/5 Front door corrosion
00411901E46/5 Fold corrosion on inside/outside of front doors
00412001E46/5 Corrosion on outside of front doors
00412101E46 (ZA) Retrofit A-pillar sealing plug
00412301E65 Check tailgate for cracks
00412401E39 Checking front spring strut support
00412501R50 R53 Screw connection, door hinge
00412601E36/7 S50 Checking bracket for final drive unit
00412701E46 Side panel, front right
00412801E67 Retrofitting auxiliary bracket for rear head airbag
00412901E63 Sealing boot lid
00413001R52 Checking welds on sill panel
00413101E53 Checking ground pin for negative battery negative lead
00413201E87 Reworking ground pin for negative battery lead
00510132E36/5 Sticker for tyre inflation pressure
00510137E36/4 318tds Covering for cooling air intake
00510138E34 with electrical seat adjustment safety ring
00510139E36 Convertible cover flap covering
00510140E36 convertible US Tyre pressure information plate
00510141E36/3 Gas filled spring holder for boot/trunk
00510142E31 A Noise insulation
00510143E36 CAB Front reinforcement cross
00510144E36/4 Seat fastenings
00510145E36 Compact - Rear side window is not tight
00510146E38 Door handle holder for Bowden cable
00510201E39 540iA Raising the total weight when fully equipped
00510301Z3 Incorrect/missing colour indicator shield
00510401E38 SA357 Side window burglarproof glass
00510701E38US E39US Rear electrical window lifter does not function
00510801E39 US/CAN Broken glove compartment opening handle
00511001E38, E39, E31 - Observation of the paint
00511401E36/Z3 - Pin for door arrester strap
00511501E36/5 - Bearing mount on rear bench seat
00511601E38 Damper elements safety glass
00511901E36/7 Guide plate catch hook (USA only)
00512001E38/3 Windscreen leaking
00512101E31 E36 E38 E39 Mechanical key code incorrectly documented
00512201E46 ACT airbag, A-pillar
00512401E39/3 Side window corrosion
00512501E38 (With SA 316) Rubber grommet of hydraulic unit
00512601E46 Jacking point loose
00512701E36/7 Tyre pressure information plate
00512901E39 M52 M62 Incorrect installation of heat insulator for rear silencer
00513001E39 M5 Adhesive joint of rear spoiler
00513201E36/7 Bonnet (hood) lock pin, lock nut
00513301E46/2 Tailgate grip handle
00513401E39 S62 Bottom cover of rear bumper
00513501E53 Correction of roof load specification
00513601E53 Replacing window frame finisher on rear doors
00513701E46/2 Door will not open
00513901E46/C Air conditioning, front screen - no GPS reception
00514001E46/3 Tailgate window does not open via pushbutton
00514101E52 Replace rear lid/tailgate damper
00514201E53 M62 Oil filter line chafes against brake line (units carrier)
00514301E38 Incorrect installation of rear door stop
00514401E46 Underride guard
00514501E46 No US airbag warning sign on instrument carrier
00514601E46 Expanding rivet, rear bumper
00514701E46/5 Spring package, boot lid/tailgate
00514801E46/3/4 Door sound insulation (front left) not tight
00514901E46/5 Space saver spare wheel retaining fixture broken
00515001E53 Bonding of outside mirror glass
00515101E46/C US Bowden cable, luggage compartment emergency release
00515201E46/4 (Korea) Replace outside mirror
00515301E46/5 M47 Replace fuel tank filler pot
00515401E46 S54 Bumper, towing eye
00515601E46/5 Tailgate prop
00515701E53 Replace tailgate handle trim
00516101E46/5 Under tank panelling
00516201E65 Retrofit emergency release for tailgate
00516501E65 E66 Rotary latch lock
00516601E46 Retrofit heat shield
00516701R53 Replace rear spoiler
00516801R50 R53 Threaded connection of battery support bracket
00516901R50 A-pillar clip (water inlet)
00517001R50 Wiring harness, body control unit (water inlet)
00517101R50 Protective cover, body control unit (water inlet)
00517201E39/2 Replacing rear rubbing strip
00517301E53 Checking boot lid stop
00517401E65 E66 US Crash pad inlay
00517501R50 R53 - Bonnet insulation mat
00517601E46 LHD Replacing rotary tumbler lock
00517701E46/4 Replacing rear door window
00517801E65 E66 Replacing hydraulic lines for automatic boot lid
00517901E60 Replacing tension spring for boot lid
00518001E85 Reworking engine compartment shielding
00518101E46/4 US Replacing impact damper, front left
00518201E53 Retrofitting splash guard, rear
00518301E60 Replacing screw plug, luggage compartment
00518401R50 R53 Replacing sound insulation, bonnet
00518501E60 US Replacing information sticker for passenger airbag
00518601E85 (Canada) Replacing both sun visors
00518701E53 Checking boot lid servo lock, top
00518801E83 Replacing combination roller blind rod
00518901E63 E64 US Replacing sun visors (airbag information sticker)
00519001E83 Reworking undercoating
00519101R50 R53 US Retrofitting plug in wheel arch
00519201R52 Replacing trim strips for cross brace
00519301E87 Reworking cowl panel cover
00519401E87 Replacing instrument panel trim
00519501E87 Reworking cowl panel cover
00519601E87 Checking fit if cowl panel cover
00519701E46 S54 Checking cavity protection for rear axle support
00519801E46 E53 E60 E61 E63 E64 E65 E66 E67 E83 E85 (LA Japan) Retrofit. clip for ETC inter.
00519901E46/3 Replacing luggage compartment net partition
00520401E36 M3 US Replace head restraints
00520501E46 Checking threaded connection of seat backrest
00520701E46/2/4 (with SA 464/465) Backrest frame, left (through-load facility with ski bag)
00520801E46/C Fastening of seat wiring harness
00520901E46/C Microswitch for backrest lock indicator
00521001R50 (MINI) Front seat backrest adjustment
00521101R50 Mounting, child seat
00521201R50 R53 (US, Can) Mounting point, child seat
00521301E65 E66 Replacing head restraint, front
00521401E85 (with SA 711) Replacing seat padding on both seats
00521501E83 Reworking threaded connection for backrest mount, rear seat
00521601E46/2 Checking backrest cover, front seat
00521701R50 R53 Replacing Isofix covers
00521801E60 E65 E66 E67 (with SA 494) Reworking backrest heating for front seats
00521901E61 Checking latch for rear seat backrest and replacing if necessary
00540201E36/5 Open air - Folding roof sealing junction
00540301E36/7 Z3 M-roadster arrester strap of tonneau cover
00540401E52 Tonneau / wind deflector
00540501E52 Hardtop mount contact ring
00540601E85 Hall sensor, convertible top position
00540701E64 Re-securing cord for convertible top
00540801E64 Reworking convertible top
00540901R52 Adjusting convertible top (buffer)
00541101R52 US Retrofitting sleeves and protective caps on convertible top
00541201R52 (Japan) Retrofitting sleeves and protective caps on convertible top
00610131E36/4 E36/5 Light relay
00610132E36/5 (without SA 530) Rear window heating switch
00610134E36 SA314 Door lock heating relay base
00610135E36 convertible US Battery
00610136E36/3 Rear window washer
00610139E38 Fuel pump electrical connection
00610141E38 M62/740i US Thermal oil level sensor
00610142E32/E34/E36 325i US Brake light switch
00610202E83 Encoding control unit for panoramic glass roof (MDS)
00610301M3 convertible - Battery+ line rubs in the foot space
00610302E65 E66 E67 Programming control units (E065-03-12-501)
00610402E64 (VPC) Programming control units to I-04-03-500
00610501E36 US Centerlock sensor
00610502E63 E64 Programming control units (interior protection)
00610602E65 E66 E67 Programming control units (airbag warning lamp)
00610701E39 RHD Driver's seat lumbar setting
00610702E83 (SA 822) Changing vehicle order and encoding instrument cluster
00610802E64 (SA 6UB) Programming control units (activate SVS)
00610901E38 740iA US Garage door opener not built in
00610902E64 Programming control units (CVM coding data)
00611001Z3 Loose spare battery+ cable
00611002E83 (SA 494) Encoding control unit for centre console switch cluster (SZM)
00611101E36, E39 or touring - Exchange vehicle immobilization control unit with SW 03 (vehicle does 00611102 E65 E66 (LA Japan) Programming control unit (seat belt indicator lamp)
00611201E36/4 - Loose connecting cable to battery in the boot (in part SA 832)
00611202E60 Replacing light module
00611301E38/E39 - Multifunctional steering wheel illumination flickers/attach dimmer
00611302E60 E61 E65 E66 E67 Programming control units (seat occupancy detection)
00611401E39 with SA 581 - Check taxi set
00611402E87 Japan Programming control units (reversing gong)
00611501E39 US - Ignition key warning signal
00611502E87 RHD Correcting pin assignments at connector for boot lid button
00611601E39 A - Vehicle immobilization III-electronic control unit
00611602E60 E61 E63 E64 (SA 6UB) Activating voice recognition system (SVS)
00611701E38 - Undervoltage protection (cool box)
00611702E60 (SA 6UC) Activating TV function
00611801E36 convertible with SA 395 - rollover sensor
00611802E60 EU E61 EU E65 E66 E67 Performing complete encoding (seat occupancy recognition)
00611901E38 Rain sensor not encoded
00611902R50 R52 R53 Replacing airbag indicator lamp
00612001E36 316i LHD Idle current distributor
00612002E39 Encoding light check module (LCM)
00612101E46 Replace left wiper blade
00612102E87 Checking steering column switch cluster and replacing if necessary
00612201E39 (With SA 810) Change central coding code
00612202E53 E85 US Encoding telematics control unit (TCU)
00612302E60 E61 M57 Programming control units (battery discharged)
00612401E38/3 Central locking unlocking/locking independently
00612601E36/7 S50 Throttle operation remaining suspended (relay support)
00612701E46 Recode US general module
00612801E38 E39 (with SA 677 and 625) Retrofit of adapter lead, DSP amplifier
00612901E36/7 M44 S50 S52 Short-circuit on B+ cable
00613001E36/7 M Roadster/coupe US ASC switch/indicator lamp
00613101E36/7 B+ lead loose at battery terminal
00613201E36/7 Retrofitting adapter lead for CD changer-radio
00613301E36/7 M43 LHD Retrofitting set of cables for speedometer signal
00613401E38 E39 (not including E38/3 and E39/2) Encode general module
00613501E39/3 Retrofitting ground lead
00613601E36/7 US Replacing clutch switch and support bracket for B+ distributor
00613701E36/7 US Replacing clutch switch for starter inhibit
00613801E36/7 M43 (without SA 530) Retrofitting double temperature switch
00613901E46 M47 (with SA 520) Outside mirror heating defective (incorrect door wiring harness)
00614001E38/3 Vehicle battery discharges
00614101E39 Reconnecting line for tailgate lock
00614201E38 E39 E46 Replacing brake light switch
00614301E46/4 One-touch function, rear door window
00614401E46 Crimping of seat wiring harness faulty
00614501E38 M73 Replacing system battery
00614601E38 M73 Replacing disconnecting switch
00614701E36/7 M43 RHD Electrical connection, secondary air pump
00614801E39 M54 Re-encode LCM (VPC only)
00614901E39 Retrofitting wire in telephone wiring harness
00615001E53 A RHD Wiring harness installation, gear indicator
00615101E53 RHD Button for upper tailgate lock
00615201E38/3 (with SA 182) Replace temperature switch
00615301R50 R53 MINI Encode key transponder
00615401E65 Program control units
00615501E65 Program control units (VPC)
00615601E46 Replace housing, OBD connector
00615701E65 Program control units (wiper module)
00615901E65 Program control units / emergency call switch
00616001E65 Encode high beam
00616101E46 Retrofit wiring harness module
00616301E65 Replace tailgate button
00616401E65 Program control units (integration stage 6.70)
00616501E65 US Replace aerial/antenna amplifier + key - program ECU
00616601E65 Program control units (I 6.54, I 6.55)
00616701E46 S54 (JPN) Retrofitting gong line (reverse)
00616801E65 E66 Programming control units (I 6.60, I 6.70)
00616901E53 RHD Securing wiring harness, steering column
00617001E65 E66 Encoding light module
00617101E65 E66 Programming control units (I 6.6x)
00617201E38/3 Hydraulic window regulator (relay)
00617301E46/C Encoding IHKA/IHKR and CVM
00617401E39 Replacing general module 3
00617501E46 Replacing general module (pressure-sensitive finger guard system)
00617601E46 Retrofitting electric cable (mirror heating)
00617701E46/C US Retrofitting electric cable (parking aid)
00617801R50 R53 Retrofitting adapter cable with diode for auxiliary fan
00617901E65 E66 Programming control units (lower than I 6.113)
00618001E65 E66 Replacing battery
00618101E38/3 SA 182 Sealing temperature switch
00618201E60 Replacing CAS control unit
00618301E60 KNG Replacing steering column trim
00618401E60 US Programming control units (SGM) - VPC
00618501E60 US Checking rear power distribution box
00618601E46 Encoding LSZ (light switch centre)
00618801E60 US Retrofitting felt
00618901E60 HEA (national version Japan) Programming control units (CCC)
00619001E60 Programming control units (on-board monitor)
00619101E65 E66 US Encoding control display (CD)
00619301E83 Replacing general module (power window)
00619401E63 Programming control units (E060-03-12-527)
00620201E39 Engine oil level control light does not function
00620301E39/2 - Pictogram display in the combi
00620601E38 E39 With SA 536 replacement instrument cluster
00620801E46 Japan version, instrument cluster software
00620901E36/7 US (not including M-models) Re-encoding instrument cluster
00621001E38 E39 - Changing central encoding code (large-scale test brake light switch SA 037)
00621101E38/3 Tank characteristic curve coded incorrectly
00621201E39 Re-coding central encoding code
00621301E52 (ECE) Replace integrated body electronics module (IKE)
00621401E65 Replace instrument cluster - speedo dial face
00621501R50 Belt warning - recoding instrument cluster
00621601E65 E66 Clock in instrument cluster
00621701E46 Replacing instrument cluster
00621801E53 N62 Replacing instrument cluster
00621901R50 R53 Encoding instrument cluster (RPA)
00630301E31 Low beam headlights and fog light
00630401E36/5 Replace rear lamp
00630501E46 LHD Replacement of front headlights and turn indicators
00630601E38 Failure of xenon headlight
00630701E38/3 (With SA 144) retrofit lever, rotating beacon
00630801E46 RHD Incorrect installation of headlight
00630901E46/2/C Direction indicator light loose
00631001E85 Replacing headlight
00640117E36 (without /5) Ventilation flap touches
00640118E34 M50 Air-conditioning compressor screw connection
00640121E38 Independent heater blower
00640122E38 Independent heater holder
00640123E38/M73 - Induction pipe to air-conditioner - USA,Japan,Canada
00640124E36 328i Air-conditioning compressor
00640125E38 - Induction pipe to air-conditioner (without USA,Canada,Japan)
00640201E39 SA538 Function failure of latent heat storage
00640301E38 Leaky air-conditioning condenser
00640501E31 Leaky air-conditioning condenser
00641001E38/M52 Garbled integrated heating and air-conditioning display indicator
00641101E38, E39 with SA 536 Independent heater automatically active
00641201E31 - Leaky heat exchanger
00641301E46 M47 LHD Hose clips, coolant hoses
00641401E46 M47 Starting problems with supplementary heater
00641501E46 SA 534 Pressure line leaking
00641601E46 M47 Bracket for supplementary heater
00641701E39 (for option SA 538) Replace latent heat storage device
00642001E39 M52 Leak in intake line for air conditioning
00642101E39 540iA (CKD Mexico) Replacing engine supply and return hoses
00642201E38 M57 Replacing control panel for automatic air conditioning (IHKA)
00642301E38 M52 Auxiliary water pump, connector pin assignments
00642401E39 M57 Control panel for heating/air conditioning - auxiliary heater function
00642501E39 M57 Replacing IHKR / IHKA control panel
00642601E46 M47 Auxiliary water pump
00642701E46 M47 without SA 530, 534 cut-off relay for heating/fuse assignments
00642801E46 M47 M57 Correct fuse assignments for auxiliary water pump
00642901E46 (With SA 530) adapter lead pressure sensor, air conditioning system
00643101E36/7 M54 Intake line, A/C compressor
00643201E38 E46 E52 E53 Electric (auxiliary) fan
00643301E39 E53 Electric auxiliary fan
00643401R50 (MINI) Seat heating
00643501E39 Electric fan (Kuwait police)
00643601E38 E39 E46 E52 E53 Electric fan - USA, Canada, Japan
00643701E38 E39 E52 E53 Electric auxiliary fan
00643801E39 M47 M57 LHD Electric auxiliary fan
00643901E46 M47 LHD Re-encode air conditioning operating unit
00644001E39 M54 Electric auxiliary fan
00644101R50 Attach pressure line air conditioner scuff protection
00644201E65 E66 N73 Replacing electric fan (pressure fan)
00644301E53 Filling air conditioning system
00650112E38 SA609 Navigation positioning
00650113E38 SA609 Navigation selection
00650114E38 SA609 Navigation CD-Software
00650115E31 Antitheft warning system
00650116E38 Jap Radio speed-dependent volume control
00650121E31,34,36 US Airbag-electronic control unit
00650122E38/US and ECE with SA-806, or SA-352 Radio receiver
00650301E38 Faulty side airbag electronic control unit
00650401E38 E39 Ocean radio onboard monitor fails
00650501E38 CD-Road map is stuck
00650701E39 - Amplifier for DSP (incorrectly built in)
00650801E39/2 Amplifier connection for FM is incorrectly poled
00650901E32/3, E38/3 - Pressure switch for fresh air system
00651101E36 RHD with SA 260 - Side airbag
00651201E38US E39US Fault in navigation system SW 7.0
00651301E36/4 Side airbag module
00651401E38 E39 Front side airbag
00651501E36/Convertible with SA 674 sound volume faulty
00651601E38 L7 Video recorder securing parts loose
00651701E36/C Harmon Kardon hi-fi system
00651801E46 GPS receiver defective
00651901E38/3 Fire extinguishing system/air system trips
00652001E46 Radio navigation operating software
00652101E36, E39 Replacement radio Business CD RDS
00652301E46/4 Subwoofer connection
00652401E38 (for option SA 302) Replace microwave interior motion sensor(FIS)
00652501E46 ITS, fit of inflator assembly
00652601E38 E39 Japan, video module software error
00652701E38 E39 (mit SA 677) Replacing DSP amplifier
00652801E38 E39 Replacing DSP amplifier + retrofitting adapter lead
00652901E46 Navigation Alpine software error
00653001E36/7 coupe retrofit DWA interior space protection
00653101E46 Airbag central triggering unit
00653201E36/7 Replacing side airbag sensors
00653301E46 Side airbag plus retaining clip
00653401E36/7 Retrofitting power supply line for daytime running lights module
00653601E46/2/3/C RHD Alpine on-board monitor
00653701E36 M3 US Re-encoding airbag control unit
00653801E53 Total failure of navigation computer
00653901E46 CKD Mexico impact sensor/re-encoding airbag control unit
00654001E46 CKD Mexico re-encoding airbag control unit
00654101E38 (without M73) E39 E46 navigation computer adapter lead
00654201E38 M73 Navigation computer adapter lead
00654301E52 US Radar passenger compartment protection SDR
00654401E39 Radio, sound distortion
00654601E39 US Reprogram/replace radio (ALPINE)
00654701E39 US Reprogram radio (VDO)
00654801E53 Antenna amplifier, voltage supply
00654901R50 R53 (MINI) Side airbag
00655101E39 E46 US Program radio receiver (VPC)
00655201E39 US Re-encode radio
00655301R50 MINI Driver's airbag - PIN assignments
00655401R50 R53 MINI Replace Boost CD53 radio
00655601E39 E46 E53 Replace ALPINE MD53/CD53 radio
00655701R50 MINI Replace Boost MD53/CD53 radio
00655801E39 E46 E53 Program ALPINE CD53 radio
00655901E65 Code sensor B-pillar right (SBSR)
00656001E65 Replace airbag control unit/satellites
00656101E65 Replace (Japan) aerial/antenna amplifier
00656201R50 R53 (SA 650) Program CD53 radio
00656301R50 R53 Radio CD 53 - remove Y-cable
00656401E65 E66 Replacing central gateway module (ZGM)
00656501E46 Recoding airbag control unit
00656601E65 E66 Replacing Central Gateway Module (scope 2)
00656701E46 - Reprogramming navigation computer
00656801E46/5 - Replacing TV amplifier
00656901E39 E53 US Retrofitting RC filter for on-board monitor radio
00657001E39 E46 Navigation software update
00657101E65 US (SA 603) Re-encoding control display
00657201E39 E53 Encoding DSP amplifier (USA only)
00657301E39 E53 Encoding DSP amplifier / replacing RC filter
00657401E85 Replacing video module
00657501E65 E66 Replacing seat occupancy detection mat, front seats
00657601E60 (VPC Japan) Programming CCC - Siemens
00657701E39 Replacing airbag control unit
00657801E60 Replacing on-board monitor and programming control units
00657901E85 US Encoding airbag control unit
00658001E85 Encoding airbag control unit (SIM)
00658101E83 Replacing front airbag sensors
00658301E85 Checking airbag components and replacing if necessary
00658401E63 E64 Replacing interior motion sensors
00658501E87 Replacing radio
00658601E87 Replacing antenna amplifier
00658701E60 Retrofitting language version Chinese (SA 866)
00658801E60 Retrofitting language version Korean I (SA 867)
00658901E60 Retrofitting language version Korean II (SA 867)
00659001E83 E85 (with SA 609) Loading navigation software
00660104E36 AUS Radio remote control 315Mhz
00660301E46 PDC Ultrasonic transducer incorrectly fitted
00660401E60 E61 E65 E66 Replacing ACC sensor
00670201E87 Checking pressure-sensitive finger guard system and replacing power window drive if 00710111 E36 M44 US Exhaust instruction plate
00710201E36/5 316i Incorrectly filled in vehicle registration documents
00710301E36/7 S52 Exhaust emission information plate incorrect
00710401E36/7 E39 S50 S52 S62 M-Mobility system hose routing
00710501E53 Jack mounted incorrectly
00710601E46/C Tyre inflation pressure sticker incorrect
00710701E36/7 Tyre inflation pressure sticker incorrect
00710801E46 US emission label fitted incorrectly in engine compartment
00710901E46 Replace tyre inflation pressure sticker
00711001E65 Retrofit exhaust emission sticker
00711101E53 (4.6is) Retrofit tyre inflation pressure information plate
00711201R50 R53 US Replace barcode sticker
00711301R50 US Replacing tyre inflation pressure information plate
00711401E39 US - Tyre inflation pressure sticker
00711501E65 E66 Retrofitting information sign, vehicle jack
00711601E60 US Replacing Compliance sticker
00711701E60 Replacing type identification plate
00711801E60 US Retrofitting GRAV information sticker
00711901R50 R53 Checking ECE type identification plate and replacing if necessary
00712001E83 (with SA 838) Replacing information sticker
00712101E83 (SA 838) Replacing information sticker
00712201E67 Replacing tyre inflation pressure sticker
00712301E83 Checking labelling on cover of OBD socket and retrofitting if necessary
00712401E87 Replacing screw connection of towing hitch
00712501E83 M54 US Checking emission information label MY05
00720114E36 Compact Child's safety belt
00720115E36/2, 4 with SA 465 - Rear safety belt
00720201E38 Loose passenger airbag
00720501E36/7C Upper belt retractor rests on B-pillar
00720601E38 Replacing head airbag, rear (C-bag)
00720701E32/3 Checking emergency exit
00720901E53 Roof rack threaded connection
00721001E53 Seat belt threaded connection, front
00721101E53 Seat belt anchorage, rear
00721201E46/2/4 US Upper belt, child safety lock, rear
00721301E39 E46 E52 Checking belt buckles
00721401E46/2/C Screw connection, airbag module, door, left
00721501E53 E85 Checking date of manufacture of seat belt tensioner
00721601E63 Replacing both rear seat belts
00721701E61 Checking screw connection for rear centre seat belt
00721801E65 E66 Checking airbag module at front door and replacing if necessary
00721901E60 US (without SA 465) checking rear centre upper belt
00820101E36 E46 E39 E38 Replace baby seat
00840201E39 touring - Telephone-data-fax interface
00840301E38 with SA 622 - Tandem telephone system
00840401E38 E39 Incorrect installation of interface telephone (Arabian countries only
00840501E38 E39 (with SA 629 and 677) - Voice input control unit
00840601E38 E39 With SA 620 without SA 677 - Voice input control unit with cooling plate
00840901E39 E53 ECE Cordless handset adapter lead
00841001E38 E39 E46 (SA 632) Replacing interface + electronic charger for hands-free system
00841201E65 Replace transceiver
00841301E39 Retrofitting adapter lead for cordless telephone handset
00841401E65 E66 US Programming transceiver
00841501E39 Replacing electronic charger/hands-free module
00841601E65 E66 (Japan) Encoding flexible BUS interface (FBI)
00841701E39 E46 Replacing universal charger and telephone hands-free facility
00841801E60 US (VPC) Replacing TCU (telematics control unit)
00841901E46 E60 US (VPC) Replacing TCU (telematics control unit) II
00842001E46 E60 US Replacing TCU (telematics control unit) II
00842101E83 E60 E65 E66 US (VPC) Replacing telematics control unit TCU
00842201E46 E53 E83 E85 Replacing or retrofitting telematics control unit TCU
00842301E46 E83 Retrofitting telematics control unit (TCU)
00990301E36/7 M54 B30 Owner's Handbook missing/incorrect
00990401E36/7 M54 B30 Mistake in Owner's Handbook
00990601E65 Replace Owner's Handbook
00990701E65 US Operating instructions (automatic emergency call)
00990801R50 R53 Supplementary Owner's Handbook, Australia
00990901E65 E66 Owner's handbook (automatic emergency call)
00991001E60 (KNG, PMT) Working through defect list
00991101E60 PMT Replacing windscreen drip moulding (work through defect list)
00991201E60 PMT Replacing cowl panel retaining clips (work through defect list)
00991301E60 PMT Replacing rear window bottom cover (work through defect list)
00991401E60 PMT Replacing drink holder (work through defect list)
00991501E60 PMT Replacing sun visor (work through defect list)
00991601E60 PMT Replacing B-pillar trim (work through defect list)
00991701E60 PMT Checking rear bench seat centre armrest, reworking if necessary (work through defect 00991801 E60 PMT Replacing safety-gateway module (work through defect list)
00991901E60 PMT Replacing fuse for micropower module (work through defect list)
00992001E60 PMT Replacing rain-light sensor (work through defect list)
00992101E60 PMT Retrofitting corrugat. tubing for wiring harness in bonnet hinge area (work thr. 00992201 E60 PMT Retrofitting corrugated tubing for Servotronic line (work through defect list)
00992301E60 PMT Retrofitting foam mater. strips + absorber at intake, right/left (work through defect 00992401 E60 PMT Replacing wiper arm (work through defect list)
00992501E60 PMT Retrofitting raised brake light with felt strips (work through defect list)
00992601E60 PMT Programming all control units (work through defect list)
00992701E60 PMT Replacing ARS/AFS return line (work through defect list)
00992801E60 PMT Replacing expansion hose for power steering (work through defect list)
00992901E60 PMT Checking power steering pump and replacing if necessary (work through defect list)
00993001E60 PMT Replacing bottom steering shaft (work through defect list)
00993101E60 PMT Replacing Owner's Handbook (work through defect list)
00993201E63 PMT Fixing wiring harness DSC
00993301E63 PMT Replacing towing eye
00993401E63 PMT Replacing radiator mounting screws
00993501E64 PMT Reworking threaded connection for convertible top main bearing
00993601E64 PMT Retrofitting cable strap on convertible top
00993701E64 PMT Replacing clip for A-pillar cover
00993801E64 PMT Replacing fuel tank ventilation line (engine side)
00993901R50 R53 Enclosing supplement in Owner's Handbook (RPA)
00994001R50 R53 US Enclosing RPA supplement in Owner's Handbook
00994101R52 PMT Replacing roof cassette and retrofitting protective cap
00994201R52 PMT Reworking convertible top
00994301R52 PMT Convertible top optimisation measures
01120139Noise/vibration when starting engine Unpleasant noises
01120157Noise/vibration when starting engine Vibration / oscillation
011201XXNoise/vibration when starting engine
0112XXXXNoise/vibration when starting engine
01130139Noise/vibration when stationary with engine running Unpleasant noises
01130157Noise/vibration when stationary with engine running Vibration / oscillation
011301XXNoise/vibration when stationary with engine running
01131139Without engaged gear/drive range Unpleasant noises
01131157Without engaged gear/drive range Vibration / oscillation
011311XXWithout engaged gear/drive range
01131239With engaged gear/drive range Unpleasant noises
01131257With engaged gear/drive range Vibration / oscillation
011312XXWith engaged gear/drive range
01131339With air-conditioning unit on Unpleasant noises
01131357With air-conditioning unit on Vibration / oscillation
011313XXWith air-conditioning unit on
01131439With electrical consumers on Unpleasant noises
01131457With electrical consumers on Vibration / oscillation
011314XXWith electrical consumers on
01131539At full steering lock Unpleasant noises
01131557At full steering lock Vibration / oscillation
011315XXAt full steering lock
0113XXXXNoise/vibration when stationary with engine running
01148739Acceleration in forward gears/stages Unpleasant noises
01148757Acceleration in forward gears/stages Vibration / oscillation
011487XXAcceleration in forward gears/stages
01148839Accelerating in reverse gear Unpleasant noises
01148857Accelerating in reverse gear Vibration / oscillation
011488XXAccelerating in reverse gear
0114XXXXNoise/vibration when accelerating
01168739Constant driving speed in forward gears/stages Unpleasant noises
01168757Constant driving speed in forward gears/stages Vibration / oscillation
011687XXConstant driving speed in forward gears/stages
01168839Constant driving in reverse gear Unpleasant noises
01168857Constant driving in reverse gear Vibration / oscillation
011688XXConstant driving in reverse gear
0116XXXXNoise/vibration at Constant driving
01178739Deceleration in forward gears/stages Unpleasant noises
01178757Deceleration in forward gears/stages Vibration / oscillation
011787XXDeceleration in forward gears/stages
01178839Decelerating in reverse gear Unpleasant noises
01178857Decelerating in reverse gear Vibration / oscillation
011788XXDecelerating in reverse gear
0117XXXXNoise/vibration when decelerating (coasting)
01180139Noise/vibration when turning off engine Unpleasant noises
01180157Noise/vibration when turning off engine Vibration / oscillation
011801XXNoise/vibration when turning off engine
0118XXXXNoise/vibration when turning off engine
01XXXXXXComplete vehicle (symptom defect codes)

 

Labels:

Subscribe to: Posts (Atom)